玛咖多糖提取过程的原位实时监测技术研究
DOI:
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

基金项目:

国家863计划项目(2013AA102203);; 国家自然科学基金项目(31471698)


Research on In-situ and Real-time Monitoring Technology of Polysaccharide Extraction from Maca
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    研究超声辅助提取玛咖多糖及检测过程中提取液的多糖含量,同时应用近红外原位实时采集提取过程的光谱信息,通过光谱信息与多糖含量化学值之间的关系建立数学模型,从而达到实时监测提取过程中玛咖多糖的目的。研究结果表明,超声提取60 min内,多糖含量不断增加,随后增加缓慢并出现波动增长的趋势。对采集的原始光谱预处理,SG是最为有效地预处理方法,Rc和Rp最高,RMSECV和RMSEP数值最小。采用PLS、iPLS和si-PLS方法建立模型后,si-PLS所建立的模型最佳,联合4个最优的波长区间为:1 258.591~1 316.735nm,2 027.121~2 084.226 nm,2 153.93~2 210.888 nm和2 337.239~2 387.696 nm,模型的Rc、Rp分别为0.9621,0.9667;RMSECV、RMSEP分别为0.0116,0.0137。结论:采用近红外光谱可较好的预测超声提取玛咖多糖过程中提取液中的多糖含量,实现提取过程中的原位监测。

    Abstract:

    In this paper, the changes of polysaccharide content in the ultrasonic extraction process were studied. At the same time, the spectral information of the extraction process was collected by near-infrared in situ real-time monitoring technique. The mathematical model was established by the relationship between spectral information and chemical value. The results showed that the content of polysaccharide increased in the process of ultrasonic extraction and then fluctuated in 60 min. After pretreatment of the acquired primitive spectra, SG was the most efficient pretreatment method with the highest Rc, Rp value and the least RMSECV, RMSEP in all pretreatments. After modeling with PLS, iPLS and si-PLS methods, the model established by si-PLS method is the best, which combined four optimal wavelength ranges are 1 258.591-1 316.735 nm, 2 027.121-2 084.226 nm, 2 153.93-2 210.888 nm and 2 337.239-2 387.696 nm. Under the optimum model, the Rc, Rp were 0.9621, 0.9667 and RMSECV, RMSEP were 0.0116, 0.0137, respectively. In conclusion: the near-infrared spectroscopy can be used to predict the content of polysaccharide in the ultrasonic extraction of maca polysaccharide and the in-situ monitoring during the extraction process is realized.

    参考文献
    相似文献
    引证文献
引用本文

孔娜;杨雪;王禹程;黄姗芬;李云亮;马海乐;.玛咖多糖提取过程的原位实时监测技术研究[J].中国食品学报,2019,19(10):235-242

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2019-11-21
  • 出版日期:
版权所有 :《中国食品学报》杂志社     京ICP备09084417号-4
地址 :北京市海淀区阜成路北三街8号9层      邮政编码 :100048
电话 :010-65223596 65265375      电子邮箱 :chinaspxb@vip.163.com
技术支持:北京勤云科技发展有限公司

漂浮通知