单硬脂酸甘油酯对棕榈硬脂固体脂肪含量及硬度的影响
DOI:
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

基金项目:

国家自然科学基金项目(U1501214,31461660,31871758); 国家重点研发计划项目(2016YFD0400203); 广州市珠江科技新星专项(201806010144)


Effect of Glyceride Monostearate on SFC and Hardness of Palm Stearin
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    食品工业中通常利用乳化剂调控塑型脂肪的物理性质及加工性能,其中,单硬脂酸甘油酯(GMS)是应用较为广泛的乳化剂。通过考察质量分数1%,2%,4%的GMS对棕榈硬脂在不同温度下的固体脂肪含量(SFC)、硬度及微观结构的影响,发现:棕榈硬脂及其与质量分数1%,2%,4%的GMS混合物的SFC和硬度随着温度的升高而降低。GMS的添加量对棕榈硬脂SFC的影响在较高温度(21.1~33.3 ℃)下更显著,当GMS添加量高于1%时,棕榈硬脂的SFC随GMS质量分数的增加而增加。而在15~30 ℃时,4%GMS的棕榈硬脂的硬度显著高于其它质量分数,且结晶颗粒细小,结晶网络结构致密。结果表明,在温度高于30 ℃时,添加GMS可以增加棕榈硬脂的SFC及硬度,且减小其结晶颗粒粒度,赋予更为致密的结构,这对棕榈硬脂基塑性脂肪在温度较高季节的储运及品质改善提供了理论依据。

    Abstract:

    In food industry, emulsifiers are commonly used to control the physical properties and processing properties of plastic fats, where glyceride monostearate (GMS) is widely used as emulsifier. The effects of GMS (1%, 2% and 4%) on SFC, hardness, and microstructure of palm stearin were investigated at different temperatures, respectively. It was observed that SFC and hardness of palm stearin with/without GMS remarkably decreased with the increase of temperature. The influence of GMS on SFC of palm stearin was more obvious at higher temperature (21.1-33.3 ℃), and when the amount of GMS in palm stearin was higher than 1%, SFC of palm stearin increased as the concentration of GMS increasing. When the temperature ranged from 15 ℃ to 30 ℃, the hardness of palm stearin containing 4% GMS was significantly higher than those of the other samples, and more small fat crystal and denser crystal network was formed. The results showed that when the temperature was higher than 30 ℃, the addition of GMS could increase SFC and hardness of palm stearin, and reduce the size of fat crystals to form a denser network, which provides an effective basis for the storage, transportation and quality improvement of palm stearin-based plastic fats in higher temperature season.

    参考文献
    相似文献
    引证文献
引用本文

刘丽艳;李琳;李冰;万力婷;张霞;.单硬脂酸甘油酯对棕榈硬脂固体脂肪含量及硬度的影响[J].中国食品学报,2020,20(4):25-32

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2020-04-30
  • 出版日期:
版权所有 :《中国食品学报》杂志社     京ICP备09084417号-4
地址 :北京市海淀区阜成路北三街8号9层      邮政编码 :100048
电话 :010-65223596 65265375      电子邮箱 :chinaspxb@vip.163.com
技术支持:北京勤云科技发展有限公司

漂浮通知