饱和蒸汽-热泵组合干燥处理对白萝卜干燥特性及品质的影响
作者:
作者单位:

(1.河南科技大学食品与生物工程学院 河南洛阳 471023;2.粮食储藏安全河南省协同创新中心 郑州 450001)

作者简介:

刘盼盼(1997—),女,硕士

通讯作者:

中图分类号:

基金项目:

国家自然科学基金项目(31671907);国家重点研发计划项目(2017YFD0400901);河南省高校重点科研项目(20A550006);河南省科技攻关项目(182102110043)


Effects of Saturated Steam and Heat Pump Combined Drying on Drying Characteristics and Quality of White Radish
Author:
Affiliation:

(1.College of Food and Bioengineering, Henan University of Science and Technology, Luoyang 471023, Henan;2.Collaborative Innovation Center of Grain Storage Security, Zhengzhou 450001)

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    以干燥时间、能耗、VC含量、收缩及复水等为试验指标,研究饱和蒸汽-热泵组合干燥处理对白萝卜干燥特性的影响。结果表明:延长饱和蒸汽处理时间、增加处理次数可明显提高干燥速率,降低干燥时间和能耗。饱和蒸汽-热泵组合干燥与单一热泵干燥相比,白萝卜的干燥时间缩短10%~45%,干燥能耗降低13.67%~44.53%。当饱和蒸汽(处理2次,每次6~8 min)-热泵组合干燥时,白萝卜干制品品质最佳,品质特性中VC含量、复水比、白度分别为50.22 mg/100 g,4.03,63.36;质构特性中硬度、咀嚼性分别为5 457.90,2 829.68 g。在此条件下,白萝卜干制品香气纯正,辛辣味较淡,质地松软顺滑,食用品质最佳。本试验表明饱和蒸汽处理可以显著提高白萝卜的干燥速率,改善其品质。

    Abstract:

    Peony swallow is the first signature dish in shui xi of Luoyang. However, the production process is complicated. This paper took drying time, energy consumption, VC content, shrinkage and rehydration as experimental indexes to investigate the influence of saturated steap-heat pump combination drying on the drying characteristics of white radish, the main ingredient of Peony Swallow. The results showed that the drying rate and drying time could be improved obviously by lengthening the treatment time of saturated steam and increasing the number of treatment times. The drying time of white radish dried by the combination of saturated steam and heat pump was reduced by 10%-45% than that of heat pump, and the drying energy consumption was reduced by 13.67%-44.53%. The quality of dried radish products was the best when the combination of saturated steam (treated twice, 6-8 min each time) and heat pump was used. The VC content, rehydration ratio, whiteness, hardness and masticability were 50.22 mg/100 g, 4.03, 63.36, 5 457.90 and 2 829.68 g, respectively. Under this condition, white radish dry products aroma was pure, pungent flavor was light, texture was soft and smooth, edible quality was best. The experiment proved that saturated steam treatment could significantly increase the drying rate of white radish and improve its quality, which was suitable for application in the processing of peony swallow.

    参考文献
    相似文献
    引证文献
引用本文

刘盼盼,任广跃,段续,李琳琳,张萌,樊小静.饱和蒸汽-热泵组合干燥处理对白萝卜干燥特性及品质的影响[J].中国食品学报,2022,22(5):157-168

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2021-05-16
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2022-06-15
  • 出版日期:
版权所有 :《中国食品学报》杂志社     京ICP备09084417号-4
地址 :北京市海淀区阜成路北三街8号9层      邮政编码 :100048
电话 :010-65223596 65265375      电子邮箱 :chinaspxb@vip.163.com
技术支持:北京勤云科技发展有限公司

漂浮通知